Ford E-450 Econoline Super Duty

Airbag module casing is cracked.

The contact rented a 2016 U-Haul E450. The contact stated that while in the parking lot and placing the vehicle in drive, the contact tapped on the accelerator pedal, then when the brakes were applied and the vehicle suddenly accelerated. The contact removed her foot from the brake, and it continued to accelerate and crashed into a parked U-Haul truck. There were no reported injuries, fire, airbag deployment, or police report filed. It was unknown if there were any warning lights illuminated.…

Airbag cover is separating

Air bag cover separating

Lifters in engine is going out. Ford has made a TSBs for repair because lifters and camshaft was made by a third party and they are defect. Here is Technical Service Bulletin (TSB 25-2200). Vehicle is available for inspection. It was put at risk because vehicle could loose power at any time and potential crash into another car. The problem has been reproduced in 4 different Ford vehicles. Has not been inspected by manufacturer or others. No warning lights were present.

Engine camshaft and lifters failed. Truck is at a Ford dealer. Engine could fail in the middle of the road, causing an accident. This is our eighth vehicle with the same issue taken to a ford dealer in the past year. A little knocking noise started that quickly turned into a loud knocking/rattling noise. No lights came on the truck.

Sped up a bit today get in front of my husband and as I did i noticed that all of a sudden I lost power. I wasn't able to go faster than 40 mph, and I wasn't able to go into gear.

2025 E-450 Safety Recalls* Main control valve body or transmission replacement Recall incomplete INVESTOR REPORTING FOR amber alert for all 2025 E-450, as this vin shows NO ACTIVE RECALLS. Yet our factory engineers have issued this RECALL. PLEASE BROADCAST.....

We rented a Class C RV based on a Ford E-Series chassis from El Monte RV. During our trip, we experienced two dangerous tire tread separations. The first incident occurred on the third day of our trip on the highway. The right rear tire's tread detached while driving at moderate speed (~55–60 mph), causing the tire to explode. The violent separation destroyed the wheel well area and shook the entire vehicle violently. Our RV contained a [XXX] child, and we were forced to stop on the shoulder…

The contact owns a 2023 Ford E-450. The contact discovered shortly after the purchase of the vehicle, that during the manufacturing, the vehicle was improperly assembled and was missing the fasteners, the housing to the frame, and the bottom of the vehicle was missing several bolts. The dealer was contacted; however, the vehicle remained at the residence. The manufacturer was not notified of the failure. The failure mileage was approximately 22,400.